Advertisement

Tesla under investigation by U.S. agency for front suspension failures

FILE - In this April 26, 2020 photograph, the company logo shines off the rear deck of an unsold 2020 Model X at a Tesla dealership in Littleton, Colo. Tesla is reassuring its 55,000 employees that it hasn't had a major coronavirus outbreak at company facilities worldwide. In an email to workers sent Wednesday, July 15, the company said that since January it has had fewer than 10 cases of the virus that causes COVID-19 that were transmitted in the workplace.(AP Photo/David Zalubowski, File). (AP Photo/David Zalubowski, File)

DETROIT — The U.S. government’s road safety agency is investigating complaints that suspensions can fail on nearly 115,000 Tesla electric vehicles.

The National Highway Traffic Safety Administration says it has 43 complaints that linkages near the ball joints can fail, allowing contact between the tire and wheel liner.

The probe, announced Friday on the agency’s website, covers 2015 through 2017 Model S sedans and 2016 through 2017 Model X SUVs.

Read more: Tesla’s Autopilot system faces increased scrutiny after 3 crashes, 3 deaths

The agency says 32 owners complained of failures at low speeds, but 11 said the links failed on roads while travelling above 10 mph including four at highway speeds. It says the number of complaints is increasing as the vehicles age, with 32 in the last two years. Three of the highway complaints came in the last three months.

Story continues below advertisement

In addition, NHTSA says it has eight complaints that may involve suspension failures that haven’t been confirmed by photos or service records.

The agency said it has no reports of crashes or injuries.

The agency says it will investigate how often the problem happens and the safety consequences. The probe could lead to a recall.

Click to play video 'Electric vehicle growth in Atlantic Canada' Electric vehicle growth in Atlantic Canada
Electric vehicle growth in Atlantic Canada – Oct 27, 2020

A message was left early Friday seeking comment from Tesla.

NHTSA says that in 2017, Tesla issued a service bulletin describing the failure and saying that drivers could still control the vehicles “but the tire may contact the wheel arch liner.” The bulletin says vehicles with the problems were built from Jan. 19, 2016 to May 25, 2016.

But NHTSA said the complaints include 41 vehicles built before or after the range cited in the bulletin. Twenty-nine were built after the range ended.

Advertisement